Manufacturing Technology 2021, 21(2):231-240 | DOI: 10.21062/mft.2021.022
Experimental characterization of microcomposite magnetorheological elastomer
- 1 Laboratory of Studies and Research in Industrial Technology, University of Saad Dahleb Blida1, Algeria
- 2 Dynamic Motors and Vibroacoustic Laboratory, Faculty of Technology, University of Boumerdes35000, Algeria
This work presents an analysis experimental of dynamic properties of microcomposite magnetorheological elastomer (MMRE) by a dynamic mechanical analyzer (DMA). The charge of magnetized iron particles is 40% of the total volume. A dynamic mechanical analysis DMA was carried out, in the scanning mode of the amplitude of shear strain, and for magnetic field densities varying from 0mT to 325mT. The storage modulus G’ and the loss modulus G’’, of the elastomer decrease, when the amplitude of the strain increases. This trend is more pronounced under a higher magnetic flux density (250mT and 325mT). In the presence of the magnetic field, the level of these two dynamic moduli and of the damping increases considerably, passing from one value to another of the applied external magnetic field. As a result, the MR effect of MRE elastomers has increased significantly with increasing magnetic flux density.
Keywords: Microcomposite; Magnetorheological elastomers; Magnetic flux density; Dynamic mechanical properties; Iron particles.
Received: October 21, 2020; Revised: January 20, 2021; Accepted: February 16, 2021; Prepublished online: March 22, 2021; Published: April 6, 2021 Show citation
References
- WAN, Y., XIONG, Y., ZHANG, S. (2018). Temperature dependent dynamic mechanical properties of Magnetorheological elastomers: Experiment and modeling. In: Composite Structures, Vol. 202, No., pp. 768-773.
Go to original source...
- DARGAHI, A., SEDAGHATI, R., RAKHEJA, S. (2019). On the properties of magnetorheological elastomer in shear mode: Design, fabrication and characterization. In: Composites Part B, Vol. 159, No., pp. 269-283.
Go to original source...
- KUMAR, V., LEE D-J. (2019). Mechanical properties and magnetic effect of new magneto-rheological elastomers filled with multi-wall carbon nanotubes and iron particles. In: Journal of Magnetism and Magnetic Materials, Vol. 482, No., pp. 329-335.
Go to original source...
- RUI, Z., CHAO, Y., XIAO, L., ZHONG-JIN W. (2020). The numerical analysis of the magnetorheological elastomer bulging for sheet metal. In: Procedia Manufacturing, Vol. 50, No., pp. 110-113.
Go to original source...
- HAPIPI, N., AISHAH, S., AZIZ, A., SAIFUL, A. M., UBAIDILLAH, SEUNG B. C., NORZILAWATI, M., MUNTAZ H. A. K., ABDUL Y. A. F. (2019). The field-dependent rheological properties of plate-like carbonyl iron particle-based magnetorheological elastomers. In: Results in Physics, Vol. 12, No., pp. 2146-2154.
Go to original source...
- ZHANG, G., WANG, H., WANG, J., JIAJIA Z., QING, O. (2019). Dynamic rheological properties of polyurethane based magnetorheological gels studied using oscillation shear tests. In: RSC Adv, Vol. 9, No.18, pp. 10124-10134.
Go to original source...
- NAM, T. H., PETRÍKOVA, I., MARVALOVA, B. (2020). Experimental characterization and viscoelastic modeling of isotropic and anisotropic magnetorheological elastomers. In: Polymer Testing, Vol. 81, No., pp. 1062-1072.
Go to original source...
- VATANDOOST, H., HEMMATIAN, M., SEDAGHATI, R.,SUBHASH, R. (2020). Dynamic Characterization of Isotropic and Anisotropic Magnetorheological Elastomers in the Oscillatory Squeeze Mode Superimposed on Large Static Pre-strain. In: Composites Part B: Engineering, Vol. 182, No., 107648.
Go to original source...
- AGIRRE-OLABIDE, I., ELEJABARRIETA, M. J. (2018). A new magneto-dynamic compression technique for magnetorheological elastomers at high frequencies. In: Polymer Testing, Vol. 66, pp. 114-121.
Go to original source...
- MICHAL, M., S., PETR, L., PETR E., HIEP, L., C., VLADIMÍR, K., LE V., S., LUKÁ©, V., ELIF, B., TOTKA B. (2018). Evaluation of Mechanical Properties of Composite Geopolymer Blocks Reinforced with Basalt Fibres. In: Manufacturing Technology, Vol. 18, No.5, pp. 861-865.
Go to original source...
- BODNARUK, A. V., BRUNHUBER, A., KALITA, V. M., MYKOLA, M. K., PETER, K., ANDREI, A. S., ALBERT, F. L., SERGEY, M. R., MIKHAIL, S. (2019). Magnetic anisotropy in magnetoactive elastomers, enabled by matrix elasticity. In: Polymer, Vol. 16, No., pp. 63-72.
Go to original source...
- AGIRRE-OLABIDE, I., KUZHIR, P., ELEJABARRIETA, M. J. (2018). Linear magneto-viscoelastic model based on magnetic permeability components for anisotropic magnetorheological elastomers. In: J. Magn. Magn. Mater, Vol. 446, pp. 155-161.
Go to original source...
- ZUZANA, G., PAVOL, ©., ALENA, B. (2020). Microstructure and Selected Properties of Si3N4+SiC Composite. Manufacturing Technology, Vol. 20, No.3, pp. 293-299.
Go to original source...
- DRAHOMÍR G., JIŘÍ K., DALIBOR, H. (2019). Magnesium Composite Materials Prepared by Extrusion of Chemically Treated Powders. Manufacturing Technology, Vol. 19 (5), pp. 740-744.
Go to original source...
- NEDJAR, A., AGUIB, S., DJEDID, T., NOUR, A., MELOUSSI, M. (2019). Measurements and identification of smart magnetomechanical elastomer composite materials properties in shear mode. In: Materials Research Express, Vol. 6, No., 085707
Go to original source...
- SUN, S. S., YANG, J., LI, W. H., DU, H., ALICI, G., YAN, T.H., MASAMI, N. (2017). Development of an isolator working with magnetorheological elastomers and fluids. In: Mechanical Systems and Signal Processing, Vol. 83, pp. 371-384.
Go to original source...
This is an open access article distributed under the terms of the Attribution-NonCommercial 4.0 International License (CC BY-NC 4.0), which permits non-comercial use, distribution, and reproduction in any medium, provided the original publication is properly cited. No use, distribution or reproduction is permitted which does not comply with these terms.